Product ID:529F-1-26559, 26559 GRAY S/G AIR DRY ENAMEL (SUP DAT)
MSDS Date:01/02/1998
FSC:8010
NIIN:00N089525
Status Code:A
MSDS Number: CHWFP

RANDOLPH PRODUCTS CO

701 12TH ST
CARLSTADT, NJ 07072-0830
US

Emergency Phone: 800-255-3924

Info Phone: 201-438-3700

Preparer: JHR

Cage: 77672

RANDOLPH PRODUCTS CO

830 CARLSTADT, NJ 07072-0830 US

Telephone: 201-438-3700

Cage: 77672

10.0 @ 20C

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: 40%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM

10.0 @ 20C

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 5%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM/150 STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

CLEAN SPILL WITH BRISTLE BROOMS, NON-SPARKING

RTECS: 9999999ZZ

EPA HAZARDOUS WASTE CODE F003 HAZARDOUS

RTECS: 9999999ZZ

ACGIH'S TLV LIM. SOLV VAPS SHOULD BE REMOVED FROM

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:CHRONIC HEALTH EFFECTS ARE POSSIBLE
FROM LONG TERM EXPOSURE, INCLUDING DRYING, CRACKING & IRRITATION OF
SKIN. REACTS W/SKIN PROTEIN & MOISTURE & CAN CAUSE RASH,
SCALING/BLISTERING. HIGH CONCENTRATIONS MAY CAUSE HEADACHES &
DIZZINESS, ARE ANESTHETIC, & MAY HAVE OTHER CENTRAL NERVOUS SYSTEM
EFFECTS, INCLUDING DEATH.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:PREEXISTING SENSITIVITY TO SOLVENTS
CAN CAUSE HEIGHTENED REACTION TO EXPOSURE TO THIS PRODUCT. CONT
LENSES WEARERS SHOULD CONSULT PROVIDER BEFORE HANDLING - CONSULT MD
IMMED IF THERE IS EYE CONTACT.

First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. CONSULT
MD. SKIN: FLUSH W/WATER. EYES: FLUSH IMMEDIATELY W/LARGE AMOUNTS OF
WATER FOR AT LEAST 15 MINUTES. CONSULT MD. INGESTION: DO NOT INDUCE
VOMI TING. KEEP PERSON WARM, QUIET & GET MEDICAL ATTENTION. SMALL
AMOUNTS OF LIQUID ASPIRATED INTO RESPIRATORY SYSTEM DURING
INGESTION, OR FROM VOMITING, MAY CAUSE CHEMICAL PNEUMONIA OR
PULMONARY EDEMA.

Flash Point Method:SCC
Flash Point:79.0F,26.1C
Lower Limits:0.9%
Upper Limits:7.0%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . WATER STREAM WILL SPREAD FIRE. DO NOT USE WATER HOSE
STREAM.
Unusual Fire/Explosion Hazard:KEEP CONTRS TIGHTLY CLSD. ISOLATE FROM
HEAT, SPKS, & OPEN FLAME. CLSD CONTRS MAY EXPLODE WHEN EXPOSED TO
EXTREME HEAT. WATER MAY BE USED TO COOL CLSD (SUP DAT)

Spill Release Procedures:AVOID BRTHG SOLV VAP. ENSURE ADEQ VENT. AVOID
SPKS, FLAMES, & ANYTHING WHICH COULD CAUSE FIRE. ELIM SOURCE OF
SPILL, IF YOU CAN DO SO W/OUT RISK BY CLOSING VALVE, PLUGGING HOLE,
ETC. APPLY ABSORB INER T MATL (SAND, DUST, VERMICULITE) TO SPILL.
(ING 3)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:DRUMS SHOULD BE GROUNDED WHEN BEING
EMPTIED.
Other Precautions:PROVIDE NIOSH APPROVED RESPIRATORY PROTECTION AGAINST
FUMES GENERATED DURING BURNING.

Respiratory Protection:NIOSH APPRVD RESP TYPES SUITABLE FOR MATLS IN
ING SECTION REC. NIOSH APPRVD CHEM/MECH FILTERS REC WHEN VENT IS
RESTRICTED. PREC MUST BE TAKEN SO THAT PERS DO NOT BREATHE
VAPS/HAVE CONT W/EYES OR SKIN. PROT AGAINST EXPOS TO VAP & SPRAY
MIST.
Ventilation:SUFFICIENT VENT, IN VOL & PATTERN, SHOULD BE PROVIDED TO
KEEP AIR CONTAMINATION BELOW CURRENT APPLIC OSHA PEL OR (ING 5)
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA . USE PROTECTIVE CREAMS.
Work Hygienic Practices:REMOVE AND WASH CONTAMINATED CLOTHING BEFORE
REUSE. USE NORMAL HYGIENE PRACTICES DURING AND AFTER HANDLING THIS
PRODUCT.
Supplemental Safety and Health
TRADE NAME/PART #: INT/EXT METAL & WOOD. EXPLO HAZ: CONTRS TO PVNT
PRESS BUILD-UP & POSS AUTOIGNIT/EXPLO WHEN EXPOSED TO EXTREME HEAT.
REMOVE ALL NON-ESSENTIAL PERS FROM FIRE AREA. VAP IS HEAVIER THAN
AIR & CAN TRAVEL CONSIDERABLE DIST TO SOURCE OF IGNIT & FLASHBACK.

Boiling Pt:B.P. Text:>279F,>137C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:1.22
Appearance and Odor:THIN GRAY LIQUID WITH TYPICAL SOLVENT ODOR.
Percent Volatiles by Volume:57.7

Stability Indicator/Materials to Avoid:YES
AVOID STRONG OXIDIZERS, ACIDS AND ALKALIES.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:THERMAL DECOMPOSITION RELEASES CARBON
MONOXIDE AND/OR CARBON DIOXIDE.

Waste Disposal Methods:SOAK LIQS W/SAWDUST OR RAGS & REMOVE. FLUSH
W/WATER IF POSS. AVOID SKIN CONT. DISP SHOULD BE I/A/W LOC, STATE,
& FED REGS. DO NOT INCIN, CUT/WELD EMPTY CONTRS. WHEN DISCARDED
THIS MATL IS HAZ WASTE. T RANSFER LIQ TO CONTRS FOR RECOVERY/DISP.
(ING 4)

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.